Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BR031  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  FLAVORFUL FOODS, LLC. DBA LUCONI'S Address  496 S KENNEDY DR
Owner or Operator   HERTZBERG, HOWARD City   BRADLEY Zip Code   60915
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
X
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
  
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
X
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   chlorine 50-100 ppm                   Dishwasher Temperature   NA °F or label
Food Temperatures:   raw sausage 45, pasta salad 46, mushrooms 41, raw meat 39, raw sausage 44
 
General Comments
 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/15/2010 Time In  1:45 PM Time Out  3:35 PM Sanitation Score  83 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  93  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BR031  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  FLAVORFUL FOODS, LLC. DBA LUCONI'S Address  496 S KENNEDY DR
Owner or Operator   HERTZBERG, HOWARD City   BRADLEY Zip Code   60915
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*3  Observed the following potentially hazardous foods to be held at improper temperatures. 1. Raw sausage was found at 45F. 2. Pasta was found at 46F.Provide for all cold potentially hazardous foods to be held at 41°F or below at all times except during necessary periods of preparation. Owner will make sure those temperatures drop too 41F or below. 750.120 Immediate/Onsite
*41  Observed the sanitizer solution in/at the following location(s) to be too strong: Sanitizer at the three compartment sink was too strong. Provide for the sanitizer solution to be no stronger than the required concentration. 750.830 Immediate/Onsite
15  Observed the following improper non-food contact surfaces. Bare wood is showing where plates are stored under pizza service warmers. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored. 750.690 Next Inspection
22  Observed the following food contact surfaces to be unclean. 1.Freezer has food debris at the bottom of it. 2. Interior of the ice machine has mold growth on interior panel. 3. Wire shelves where pizza pans are stored has dust & debris on them. 4. Cutting board has food stains on them. Clean and maintain. 750.800 Next Inspection
23  Observed the following contact surfaces to be unclean. 1. Sides of oven & fryers has grease & debris on them. 2. Seal gaskets on reach-in coolers have food debris in them. 3. Interior & exterior of fryers has grease & debris in them. 4. Rack where wrappers are stored has dust & debris on it. 5. Bottom of the mixer has debris on it & on small table. 6. Lids have debris on them where dough is stored in the walk-in cooler. 7. Sauce rack & can rack has dust & debris on them. Clean and maintain. 750.800 Next Inspection
24  Observed knives were stored between prep tables. Knives were stored else where. 750. 830 Next Inspection
36  Observed the following floor areas to be unclean: Floor under fryers, stove, oven has grease & food debris on it. 2. Clean floor under all equipment and in back restroom. Provide for all flooring areas to be in a clean condition. 750.1220 Next Inspection
37  Obseved the following wall/ceilings, and attached equipment to be unclean: 1. Wall has grease & debris on it behind stove fryers & oven. 2. There is open space in wall by cash register. Repair this wall. 3. Fan case & ceiling in the walk-in cooler has dust built up on it. Clean this ceiling. 750.1220, 750.1210 Provide for all walls, ceilings, and attached equipment to be in a clean condition Next Inspection
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/15/2010 Time In  1:45 PM Time Out  3:35 PM Sanitation Score  83 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  93  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BR031  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  FLAVORFUL FOODS, LLC. DBA LUCONI'S Address  496 S KENNEDY DR
Owner or Operator   HERTZBERG, HOWARD City   BRADLEY Zip Code   60915
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/15/2010 Time In  1:45 PM Time Out  3:35 PM Sanitation Score  83 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  93